ABS by Bosch v. 5.3 & 5.7

[Eugen_piano]

de ceva vreme ma tot framanta un cod de eroare pe ABS, respectiv numarul 11... dar, la R200 este vorba despre Bosch ABS 5.0.

in fine, nu am gasit nicaieri o lista cu toate codurile de eroare pentru versiunea 5 fix, BUT, pentru colegii de forum, care au sub capota modelele mai noi de calculatoare de frana, voila, les codes:

Bosch ABS 5.3 (implementarea HONDA-ROVER)

11 Wheel speed sensor F.R. Circuit disconnected/ short circuited
12 Wheel speed sensor F.R. Signal error/ signal variation
13 Wheel speed sensor F.L. Circuit disconnected/ short circuited
14 Wheel speed sensor F.L. Signal error/ signal variation
15 Wheel speed sensor R.R. Circuit disconnected/ short circuited
16 Wheel speed sensor R.R. Signal error/ signal variation
17 Wheel speed sensor R.L. Circuit disconnected/ short circuited
18 Wheel speed sensor R.L. Signal error/ signal variation
21 Wheel speed sensor F.R. Electrical interruption.
22 Wheel speed sensor F.L. Electrical interruption.
23 Wheel speed sensor R.R. Electrical interruption.
24 Wheel speed sensor R.L. Electrical interruption.
31 Solenoid valve inlet. F.R.
32 Solenoid valve outlet. F.R.
33 Solenoid valve inlet. F.L.
34 Solenoid valve outlet F.L.
35 Solenoid valve inlet. R.R.
36 Solenoid valve outlet R.R.
37 Solenoid valve inlet. R.L.
38 Solenoid valve outlet R.L.
41 Solenoid valve F.R.
42 Solenoid valve F.L.
43 Solenoid valve R.R.
44 Solenoid valve. R.L.
51 Hydraulic pump Circuit failure, fuses relay wires/ connector.
52 Hydraulic pump Not activated
53 Hydraulic pump Activated.
54 ABS relay Not activated
61 Voltage supply Voltage too high/ low
62 Voltage supply Voltage too high/ low
71 Uneven wheel size
81 ABS ECU Fault/ ECU error

[Eugen_piano]

Bosch ABS 5.7 (implementarea BMW)
*daca nu ma insel, v. 5.7 este pe R75. Ma indoiesc ca producatorii de masini folosesc coduri diferite in cazul ABS sau chiar SRS, pentru ca nu ei fac sistemele in cauza; parerea mea.

Daca vede Marcell threadul, rog sa valideze sau nu codurile de mai jos:

5 Right Rear Wheel Speed Sensor
6 Right Front Wheel Speed Sensor
7 Front Left Wheel Speed Sensor
14 Solenoid Valve Relay (check fuses 17 & 33)
15 Pressure Sensor/Pump Error
21 Module Memory Failure - ABS/ASC module is faulty
23 Incorrect Coding - ABS/ASC module is faulty
24 Wrong Impulse
30 Left Rear Wheel Speed Sensor
31 Open Right Rear Wheel Speed Sensor
32 Open Right Front Wheel Speed Sensor
33 Open Left Front Wheel Speed Sensor
50 Right Front Outlet Valve - ABS/ASC module is faulty
51 Left Rear Outlet Valve - ABS/ASC module is faulty
54 Left Front Inlet Valve - ABS/ASC module is faulty
55 ASC Intake Valve - ABS/ASC module is faulty
58 Gear Box Control Unit (CAN bus error)
59 DMER1 (CAN bus error)
61 Steering Angle Sensor Identification
66 Speed Sensor Voltage Supply
67 Intermittent Interference
75 Engine Speed Fault from DME
81 Pressure Sensor
82 Open Yaw Rate Sensor
86 ASC Cut-off Valve Rear Axle
88 Precharge Pump
89 Low Voltage
90 Temporary System Deactivation
94 DDE Fault/Yaw rate sensor
97 Steering Angle Sensor
10 Brake Light Switch
108 SN Control
112 Open CAN to Instrument Cluster
114 Pressure Sensor Offset
117 Brake Light Switch Failure
118 DME Status-Internal Error

[Eugen_piano]

The Most Famous Pins:

senzori:
dreapta spate pinii 1-2 sau 1-3 (firele galben si verde),
dreapta fata 4-5,
stanga fata 6-7,
stanga spate 8-9
tester (diagnostic): 11
brake pedal switch: 14
12V principal: 15
impamantare: 16
12V solenoid: 17
12V releu pompa: 18
impamantare suplimentara: 19
impamantare becuri: 20 (pentru martor frana de mana, cred), 21 (pentru martor ABS)
comunicare ecu: 25

[Eugen_piano]

Desi codurile pentru versiunea 5.0 nu au putut fi gasite... nicaieri... am schimbat totusi intrerupatorul luminilor de frana, deoarece mi se parea ca exista un pic de joc.
Asta a fost acum cateva saptamani...

Azi am pus testerul pe masina and eroarea a disparut. Nu mai era nici macar in istoric. Everything is clean.